Aft Deck Restoration
Re: Aft Deck Restoration
I am 260 lb and do not think my original 5/8" decking feels at all springy. I have replaced the hatch and the section forward of it thus far. My hatch had gotten rotten and the section in front of it was beginning to sag in the middle over time and held water. in a pool. I need to do the three remaining sections still, they are not soft anywhere but have holes from mounted fishing chairs and down riggers.
1984 39 Marinette Sedan, " LIBERTY ONE " Warsaw KY, 440 chryslers, Westerbeke 9.0 kw , 1 3/8" shafts 93 1/4" long and 19x22 dyna quads or, 19x20 DQX's 38.5 MPH GPS best.
Re: Aft Deck Restoration
Hello, I will be starting this winter on replacing the aft deck. Do you have any finished pics. I would like to see some different finished pic. Thanks Joe
1988 sedan flybridge. Black / White. 318 240 hp Aluminum aft deck hard top. Louisville Ky . Tartans landing. " KNOCKEFELLERS"
Re: Aft Deck Restoration
I am replacing my deck and actually painting it with Olympic RESCUE IT Tintable Resurfacer . I figure I would give it a try since it is exterior rated.
https://www.lowes.com/pd/Olympic-RESCUE ... gLpvfD_BwE
https://www.lowes.com/pd/Olympic-RESCUE ... gLpvfD_BwE
1959 Family Cruiser - Sold - Gary Dick - 12/05/14
1963 Express 31x10 - Sold - Joe & Ginger Tabor - 01/21/2017
1963 Express 31x8.5 - In Dry Dock - Restore Underway
1987 Sportsman - Lay Lake (Coosa River) Alabama
Big
's Rule !!!
Columbiana, AL
1963 Express 31x10 - Sold - Joe & Ginger Tabor - 01/21/2017
1963 Express 31x8.5 - In Dry Dock - Restore Underway
1987 Sportsman - Lay Lake (Coosa River) Alabama
Big
![marinette BigM](./images/smilies/icon_e_bigM.gif)
Columbiana, AL
Re: Aft Deck Restoration
Cut new plywood decking from 5/8" exterior plywood. Had a pickup bed sprayer spray and underlap the bottom side by 6". Replaced the big washer on the cockpit drains with a big 1/4" aluminium flage that fits under the corner side walls. Tighten the cockpit drain nut and the deck is tightened down in the corners. Only put back the under deck screws I could reach.
Re: Aft Deck Restoration
Hello trying to decide on what to use, on the aft deck . Has anyone used NAUTIFLOOR ? I was looking at the 65TE . I looked at plastek. I did not like the way it was glued together. I seen a swim platform with it. It did not hold up very well. I was going to go with starboard ,Butt the wife likes the look of the teak. Thanks Joe
1988 sedan flybridge. Black / White. 318 240 hp Aluminum aft deck hard top. Louisville Ky . Tartans landing. " KNOCKEFELLERS"
Re: Aft Deck Restoration
My plasteak bowsprit held up for years with no maintenance and always looked like new (was still going strong when I sold it). With more energy for a project, I would have covered rear deck with it. Mine was T&G (tongue and groove) - no glue. For the rear deck I would have used some kind of mfr-approved sealant in the groove where two pieces lock together.
-joel-
former owner 1988 '32 FB Sedan
Chesapeake Bay
twin 318 / 240 hp
Potomac MD
former owner 1988 '32 FB Sedan
Chesapeake Bay
twin 318 / 240 hp
Potomac MD
Re: Aft Deck Restoration
I am going to replace my deck on my 32' Sedan and new acquired 26' Express.
I replaced my 32' in 2008 with marine plywood and covered with Nautolex. It is already getting spongy. I am done with wood.
What I have considered
1 Aluminum decking
Pros - will never rot
Cons - noise transmission , mounting (need to be bolted to access tanks) , ??? what do cover it with appearance, expansion and contraction , cost
2 King starboard
Pros - will never rot
Cons - strength , appearance? , cost , expansion and contraction
3 Synthetic plywood "Coosa"
Pros -will never rot, direct replacement for plywood, dimentionally stable
Cons - need to be covered, cost,
4 Wood Never again
I am planning on going with Coosa http://www.coosacomposites.com Bluewater 26. I am going to use 3/4 in ( they do not sell 5/8). approx $227 plus shipping for 4x8 sheet And cover with Nautolex or use SeaDek http://www.seadek.com
I replaced my 32' in 2008 with marine plywood and covered with Nautolex. It is already getting spongy. I am done with wood.
What I have considered
1 Aluminum decking
Pros - will never rot
Cons - noise transmission , mounting (need to be bolted to access tanks) , ??? what do cover it with appearance, expansion and contraction , cost
2 King starboard
Pros - will never rot
Cons - strength , appearance? , cost , expansion and contraction
3 Synthetic plywood "Coosa"
Pros -will never rot, direct replacement for plywood, dimentionally stable
Cons - need to be covered, cost,
4 Wood Never again
I am planning on going with Coosa http://www.coosacomposites.com Bluewater 26. I am going to use 3/4 in ( they do not sell 5/8). approx $227 plus shipping for 4x8 sheet And cover with Nautolex or use SeaDek http://www.seadek.com
Bauxite Lady
32' FB Sedan
318 Chryslers
26' Express
318
Ohio River Mile 498
32' FB Sedan
318 Chryslers
26' Express
318
Ohio River Mile 498
- shade2u2
- Royal Aluminum Star
- Posts: 290
- Joined: Mon Jul 21, 2014 3:11 pm
- Location: Marietta, Ohio -mile marker 172
Re: Aft Deck Restoration
Are there any composite decking that would work?
John
1986 39 Sedan w/Crusader 454 & 1.92 drive.
former - '84 28 Express Hardtop w/single 360 1.5:1 drive (SOLD - now in Uruguay)
Ohio and Muskingum Rivers (Marietta, OH)
1986 39 Sedan w/Crusader 454 & 1.92 drive.
former - '84 28 Express Hardtop w/single 360 1.5:1 drive (SOLD - now in Uruguay)
Ohio and Muskingum Rivers (Marietta, OH)
Re: Aft Deck Restoration
RiverRatt -- see my post of Plasteak above. The only con is cost but it's virtually forever so the cost is one time. Very easy to work with. I used a scrap piece in my garden and 20 years later, as good as new under damp, shady conditions. On the boat, it was not harmed by sun
-joel-
former owner 1988 '32 FB Sedan
Chesapeake Bay
twin 318 / 240 hp
Potomac MD
former owner 1988 '32 FB Sedan
Chesapeake Bay
twin 318 / 240 hp
Potomac MD
- shade2u2
- Royal Aluminum Star
- Posts: 290
- Joined: Mon Jul 21, 2014 3:11 pm
- Location: Marietta, Ohio -mile marker 172
Re: Aft Deck Restoration
There is a lot of this offered on Ebay...
https://www.ebay.com/itm/Marine-Boat-Fl ... 2595391696
https://www.ebay.com/itm/Marine-Boat-Fl ... 2595391696
John
1986 39 Sedan w/Crusader 454 & 1.92 drive.
former - '84 28 Express Hardtop w/single 360 1.5:1 drive (SOLD - now in Uruguay)
Ohio and Muskingum Rivers (Marietta, OH)
1986 39 Sedan w/Crusader 454 & 1.92 drive.
former - '84 28 Express Hardtop w/single 360 1.5:1 drive (SOLD - now in Uruguay)
Ohio and Muskingum Rivers (Marietta, OH)